A Southwest Airlines plane sits on the runway at the Philadelphia International Airport after it made an emergency landing in Philadelphia, on Tuesday, April 17, 2018. (David Maialetti/The Philadelphia Inquirer via AP)

Blown Southwest jet engine showed ‘metal fatigue’

The Federal Aviation Administration says the flight from New York to Dallas made an emergency landing after the crew reported damage to one of the engines

A preliminary examination of the blown jet engine of the Southwest Airlines plane that set off a terrifying chain of events and left a businesswoman hanging half outside a shattered window showed evidence of “metal fatigue,” according to the National Transportation Safety Board.

Passengers scrambled to save the woman from getting sucked out the window that had been smashed by debris. She later died, and seven others were injured.

Related: 1 dead after jet blows an engine; woman nearly sucked out

The pilots of the twin-engine Boeing 737 bound from New York to Dallas with 149 people aboard took it into a rapid descent Tuesday and made an emergency landing in Philadelphia. Oxygen masks dropped from the ceiling and passengers said their prayers and braced for impact.

“I just remember holding my husband’s hand, and we just prayed and prayed and prayed,” said passenger Amanda Bourman, of New York.

The dead woman was identified as Jennifer Riordan, a Wells Fargo bank executive and mother of two from Albuquerque, New Mexico. The seven other victims suffered minor injuries.

The National Transportation Safety Board sent a team of investigators to Philadelphia.

In a late night news conference, NTSB chairman Robert Sumwalt said one of the engine’s fan blades was separated and missing. The blade was separated at the point where it would come into the hub and there was evidence of metal fatigue, Sumwalt said.

The engine will be examined further to understand what caused the failure. The investigation is expected to take 12 to 15 months.

Photos of the plane on the tarmac showed a missing window and a chunk gone from the left engine, including part of its cover. A piece of the engine covering was later found in Bernville, Pennsylvania, about 70 miles (112 kilometres) west of Philadelphia, Sumwalt said.

As a precaution, Southwest said Tuesday night that it would inspect similar engines in its fleet over the next 30 days.

Passengers praised one of the pilots, Tammie Jo Shults, for her cool-headed handling of the emergency. The former Navy pilot was at the controls when the plane made the emergency landing. She walked through the aisle and talked with passengers to make sure they were OK after the aircraft touched down.

“She has nerves of steel. That lady, I applaud her,” said Alfred Tumlinson, of Corpus Christi, Texas. “I’m going to send her a Christmas card, I’m going to tell you that, with a gift certificate for getting me on the ground. She was awesome.”

In a recording of conversations between the cockpit and air traffic controllers, an unidentified crew member reported that there was a hole in the plane and “someone went out.”

Tumlinson said a man in a cowboy hat rushed forward a few rows to grab the woman and pull her back in.

“She was out of the plane. He couldn’t do it by himself, so another gentleman came over and helped to get her back in the plane, and they got her,” he said.

Passengers struggled to somehow plug the hole while giving the badly injured woman CPR.

As the plane came in for a landing, everyone started yelling to brace for impact, then clapped after the aircraft touched down safely, Bourman said.

Southwest CEO Gary Kelly said there were no problems with the plane or its engine when it was inspected on Sunday.

The jet’s CFM56-7B engines were made by CFM International, jointly owned by General Electric and Safran Aircraft Engines of France. CFM said in a statement that the CFM56-7B has had “an outstanding safety and reliability record” since its debut in 1997.

Last year, the engine maker and the Federal Aviation Administration instructed airlines to make ultrasonic inspections of the fan blades of engines like those on the Southwest jet. The FAA said the move was prompted by a report of a fan blade failing and hurling debris. A Southwest spokeswoman said the engine that failed Tuesday was not covered by that directive, but the airline announced it would speed up ultrasonic inspections of fan blades of its CFM56-series engines anyway.

“There’s a ring around the engine that is meant to contain the engine pieces when this happens,” said John Goglia, a former NTSB member. “In this case it didn’t. That’s going to be a big focal point for the NTSB — why didn’t (the ring) do its job?”

In 2016, a Southwest Boeing 737-700 blew an engine as it flew from New Orleans to Orlando, Florida, and shrapnel tore a 5-by-16-inch hole just above the wing. The plane landed safely. The NTSB said a fan blade had broken off, apparently because of metal fatigue.

Related: Algerian military plane crashes in a field, killing 257

___

Koenig reported from Dallas. Associated Press writers Kristen de Groot and Claudia Lauer in Philadelphia; Susan Montoya in Albuquerque, New Mexico; and Matthew Barakat in Washington, contributed to this story, along with AP researchers Monika Mathur and Jennifer Farrar.

Alexandra Villarreal And David Koenig, The Associated Press

Like us on Facebook and follow us on Twitter.

 

In this 2017 photo, Jennifer Riordan, of Albuquerque, N.M., poses for a photo in Albuquerque. Family, friends and community leaders are mourning the death of Riordan, a bank executive on a Southwest Airlines jet that blew an engine as she was flying home from a business trip to New York. (Marla Brose/The Albuquerque Journal via AP)

Just Posted

Nathan Cullen named Parliamentarian of the Year

Skeena-Bulkley Valley MP won the top-title Nov. 5

VIDEO: Taking to the skies to protect moose in the Cariboo Chilcotin

Conservation Officer Service doubles patrols to oversee moose harvest

New Coast Guard radar boosts marine traffic monitoring off B.C. coast

Six radar installations set up for Georgia Strait to Queen Charlotte Strait to Prince Rupert

Central Coast Regional District swears in new Board of Directors

There are three new faces representing our region and two returning directors

VIDEO: Black horse signals ‘sign of peace’ for Tsilhqot’in Nation

Justin Trudeau rides black horse provided by Cooper family

Saving salmon: B.C. business man believes hatcheries can help bring back the fish

Tony Allard worked with a central coast First Nation to enhance salmon stocks

High-end B.C. house prices dropping, but no relief at lower levels

But experts say home ownership remains out of reach for many for middle- and lower-income families

Worker killed in collision at B.C. coal mine

Vehicle collision occurred at approximately 10:45 a.m. this morning

B.C. asking for tips on ‘dirty money’ in horse racing, real estate, luxury cars

Action follows a Peter German report on money laundering in B.C. casinos

Canadian dead more than a week after plane crash in Guyana: Global Affairs

Global Affairs said it couldn’t provide further details on the identity of the Canadian citizen

Children between 6 and 9 eligible for $1,200 RESP grant from province

BC Ministry of Education is reminding residents to apply before the deadline

Victoria spent $30,000 to remove John A. Macdonald statue

Contentious decision sparked controversy, apology from mayor

Privacy concerns over credit card use for legal online pot purchases

Worries follow privacy breaches at some Canadian cannabis retailers

NEB approves operating pressure increase to repaired Enbridge pipeline

The pipeline burst outside of Prince George on Oct. 9, now operating at 85 per cent

Most Read